There are many times when my aspirations heavily outweigh my inspiration. It is times like these that I end up with 25 lbs of tomatoes that I wanted to wish away. They did not, however, turn themselves into the ketchup they were purchased to become nor did they disappear. They continued to ripen and I did not want to throw money away.
I made the ketchup using a new technique that I figured out because the recipes I followed last year were, frankly, a pain in the ass. Taste wise they were fine but it was really annoying to try and fit 10 lbs of tomatoes into the biggest pot I had, and still have it fall short. The recipes said to put the tomatoes in raw and cook them down and then puree them usually using a food mill. Well, I bought a food mill and I hate it. I have a food processor so no one can convince me that a food mill is better, because I am lazy. Sure, maybe you end up with a nicer texture but I don’t feel the need to add an extra hour cranking the handle on a food mill to the already long process of making ketchup. Admittedly, I do not own a really good food mill because I couldn’t really justify spending $75 on a new kitchen tool. The one I bought was $20 and I got it at Zehrs (grocery store). If anyone wants it, let me know.
Last year I made Slow-Cooker Ketchup but I prefer the texture you get when you strain the tomato puree through a fine mesh sieve. I also made Classic Tomato Ketchup but there was no way I could fit the 12 lbs of tomatoes in my big cast iron enamelled pot so I had to add them in stages. Supreme pain in the ass. This year, I still wanted the homemade ketchup but I needed to take some of the fussiness out of the method.
If you are like me and don’t have a pot large enough for 10 lbs of tomatoes, you likely have a pan big enough for a turkey. I mounded the tomatoes, chopped onion and pepper in my big stainless steel turkey roasting pan and roasted the lot for about an hour. I didn’t have to tend the pot by stirring it and keep adding the tomatoes that didn’t fit as the tomatoes cooked down. I didn’t worry about some tomatoes scorching on the bottom of the pot, or the juice boiling over. I just poked at the tomatoes with a wooden spatula after they had been cooking for a half hour. Once they were fully soft and pulpy I took them out and started to puree it all in my food processor.
While the tomatoes roasted I put all spices directly in the vinegar, brought it to a simmer, put the lid on and turned the heat off. I let the spices steep for the whole time the tomatoes roasted, except for the cinnamon. I took that out after about a half hour because it just got too strong in the first batch where I left it the whole time. I was out of cheesecloth (I totally forgot to buy some) so I strained the vinegar through one ply of paper towel. I separated the plys because I didn’t want the paper towel to absorb too much vinegar. I also moistened the paper towel so it sat better in my little sieve.
The pureeing and straining process is a little time-consuming. With the size of my sieve and food processor, I have to puree all the tomatoes in 4 batches. Not really hard work, just a little fussy. The best way I have found to push the puree through the sieve is to use a strong whisk and push the pulp through the sieve. By stirring the puree with the whisk you can push the puree through and scrape the bottom of the sieve at the same time.
Here are my final tips for you if you are jumping on the homemade ketchup bandwagon: wear black and long sleeves. The ketchup splatters a lot and if you are fool enough to wear a tank top like I was, a molten hot ketchup splatter will likely find your bare skin. I still have the mark on my shoulder. I’m just happy that Timothy wasn’t in the room to hear my colourful choice of words when I got my ketchup scald.
- 10 lbs plum tomatoes (such as San Marzano)
- 1 medium onion, chopped (3/4 cup)
- 1 red bell pepper, chopped (3/4 cup)
- 1¾ cup cider vinegar
- 2 tbsp mustard seeds
- 1 tsp whole cloves
- 1 tsp celery seeds
- 1 tsp whole allspice
- 1 tsp whole peppercorns
- 1 cinnamon stick
- 1½ tbsp salt
- 1¼ cup lightly packed dark brown sugar
- Preheat the oven to 400 degrees F.
- Wash and cut all the tomatoes in half and place them in a large roasting pan.
- Chop the onion and bell pepper and mix them in with the tomatoes.
- Place the roasting pan in the oven and roast for an hour. Half way through cooking, stir the tomatoes around so that the tomatoes on top don’t end up burnt.
- When the tomatoes go into the oven, put the cider vinegar in a small pot with all the spices. You will strain them out later. After a half an hour, remove the cinnamon stick or it becomes overpowering.
- When the tomatoes are soft and pulpy, take them out of the oven and puree them in batches in a food processor.
- Separate a piece of paper towel into its two individual plys. Lightly moisten one ply of paper towel and place it over a small fine mesh sieve. Pour the vinegar over the paper towel to strain out the spices. Discard the spices and paper towel. Set the spiced vinegar aside.
- Put the puree in a fine mesh sieve set over a very large heat proof bowl, also in batches, and push it through using a strong whisk, using a stirring motion.The whisk will push the puree through the sieve while it scrapes the bottom of the sieve allowing you to get the pulp through faster. Discard the seeds and skin left behind in the sieve. Scrape the pulp stuck to the underside of the sieve into the bowl.
- When the tomatoes are all strained through the sieve, pour the pulp into a large heavy bottomed pot. I use a 5 quart cast iron enamelled pot.
- Pour the spiced vinegar into the pot with the tomatoes. Stir in the brown sugar and salt as well.
- Bring the mixture to a boil over a medium high heat.
- While that starts to boil, bring a canning pot full of water, with a rack on the bottom, to the boil.
- Wash 6 half pint (250 ml) jars and new lids. Put the clean jars in the canning pot to sterilize. Boil them for 10 minutes and then turn off the heat to keep the jars hot and ready for the ketchup.
- Keep stirring the ketchup often to prevent scorching on the bottom.
- When the ketchup is less watery (after about a half hour) and is starting to splatter, place a spatter guard on top of the pot or prepare to clean up a lot of ketchup splatters from your stove, floor and counter. Also, turn the heat down to medium.
- Continue to boil the ketchup over a medium heat, stirring often as it cooks down until it is very thick.
- About ten minutes before the ketchup is done, put the lids of canning jars in small pot with water and heat it gently on the stove for 5 minutes. Put the lid on it to prevent ketchup splatters from getting in the pot. Once the water is hot, turn the heat off and let the lids sit in the hot water.
- To test to see if the ketchup is thick enough, take a spoonful and put it on a plate. If it stays in a mound and hardly any liquid spreads out on the plate then it is done. If a watery pool forms around the ketchup then keep boiling it down. You may need to boil the ketchup for upwards of an hour and a half to get the consistency of a nice thick ketchup.
- When the ketchup is the consistency you want, take the jars out of the hot water and place them on a heat proof surface, such as a large cutting board. Fill the jars with the ketchup, leaving ½ inch head space.
- Wipe the rims of the jars and place the hot lids on and rings. Tighten the rings (but not too tight) and place the jars in the boiling water of the canning pot and boil the jars for 10 minutes. Ensure that the water is boiling the entire time.
- When the time is up, remove the jars from the water and place on a rack or board. Leave the jars for 24 hours and if they seal then they can be stored in a cool dry place. If they do not seal then refrigerate them and use within a couple of weeks.
Entry filed under: Condiments, Preserves and Jams, Preserving, Recipes. Tags: As Canadian as ketchup chips, condiments, food processor, grilled cheese and ketchup, homemade ketchup, ketchup splatters, no need for cheesecloth, oven roasting, plum tomatoes, real food, tomatoes.
September 25, 2013